ENGINEER

Question 1

TYPE OF ENGINES?

Answer 1

Twin Detroit Diesel Series 60 engines with DDEC IV

Question 2

TYPE OF WATER JETS?

Answer 2

Twin Kamewa FF3755 Waterjets

Question 3

TYPE OF REDUSTION GEARS?

Answer 3

Twin Disc MG5114SC Reduction Gears

Question 4

ENGINE HORSE POWER?

Answer 4

825 HP

Question 5

FUEL CAPCITY?

Answer 5

510 GALS @ 100% 485 GALS @ 95 % 468 GALS USEABLE

Question 6

HOT START TYPE?

Answer 6

The Kim Hot Start 1500W

Question 7

HOT START TEMP?

Answer 7

120* @ 0* F OUTSIDE

Question 8

SECONDARY FUEL FILTER RATED @?

Answer 8

8 MICRONS

Question 9

The fuel tank is located between Frames?

Answer 9

3.5 & 10

Question 10

FUEL SOUNDING ROD IS MARKED IN ____ INCREMENTS….

Answer 10

25 GALS

Question 11

The Fuel Tank Vent is located?

Answer 11

Starboard side of the boat between Frames 7 and 8.

Question 12

Type of fuel vent?

Answer 12

Inverted ball check valve

Question 13

What does the “come home” feature do?

Answer 13

Permits a mechanical lock-up of the clutch

Question 14

Situations that

may require use of come-home are?

Answer 14

1. Loss of hydraulic pump pressure

2. Loss of oil.

Question 15

Reduction Gear ratio?

Answer 15

1.02 : 1

Question 16

Sea suction valves location?

Answer 16

Between the Transom and Frame 1 on both sides of the keel in the Lazarette

Question 17

Sideways movement of the boat is controlled by?

Answer 17

The Steering Nozzle

Question 18

Full steering locks @?

Answer 18

30 degrees

Question 19

Type of Trim Tabs?

Answer 19

“Interceptor” Trim Tabs

Question 20

Interceptor trim tabs are located on the?

Answer 20

lower outboard section of the water jet.

Question 21

The Hydraulic Tank is located?

Answer 21

In the Engine Room port side between frame 5 and 6.

Question 22

The hydraulic tank holds______gallons of hydraulic fluid?

Answer 22

9

Question 23

Transducer is located in the?

Answer 23

Lazarette

Question 24

The PSEA Ethernet Hub is located in the?

Answer 24

Auxiliary Machinery Compartment on the

aft bulkhead centerline

Question 25

Electrical power is supplied by?

Answer 25

Two Auragen Power Generation Systems. Belt driven generators.

Question 26

How many battery banks are there?

Answer 26

2......The Start Battery Bank and The House Battery Bank

Question 27

What does the START battery provide power to?

Answer 27

provides 24-VDC power for diesel engine starting and 24P2 DC Power Panel

Question 28

What does the HOUSE battery provide power to?

Answer 28

provides 24-VDC to the 24P1 and 24P3 DC Power Panels.

Question 29

True or False....The battery | banks operate independent of each other.

Answer 29

True

Question 30

In the event of an emergency, the battery banks can be?

Answer 30

cross-connected through manual operation of the Automatic Charging Relay.

Question 31

R/G Oil Pressure (disengaged):

Answer 31

Normal 15-65psi, Disabling 65

Question 32

R/G Oil Pressure engaged (2300 rpm):

Answer 32

Normal 185-265psi, Disabling 265

Question 33

R/G Oil Temp

Answer 33

MAX of 193°

Question 34

Normal Engine Temp:

Answer 34

MAX of 211°

Question 35

Lube oil pressure @2300RPM

Answer 35

Normal >41psi Disabling <31psi Alarm sounds at 30psi

Question 36

Bilge Pumps

Answer 36

33GPM x 6

Question 37

Lube oil pressure @ 650RPM

Answer 37

Normal >10 Disabling <10

Question 38

Coolant capacity

Answer 38

15 Gallons of Power Cool 50/50 pre-blend

Question 39

Engine oil capacity

Answer 39

43 quarts of 15W40

Question 40

Shaft rotation

Answer 40

Left hand rotation (Aft looking fwd)

Question 41

Block formation

Answer 41

Inline six cylinder (meaning there are six cylinders in a row instead of three on each side)

Question 42

Jacket water Temp

Answer 42

Normal-140-185F, Restrictive- 186-211, Disabling and Alarm sounds at 212F

Question 43

Jacket water flow rate

Answer 43

178 GPM

Question 44

Raw water flow rate

Answer 44

125 GPM

Question 45

Reduction Gear--Oil Capacity

Answer 45

2.8 Gal. 15W40