2014 Flashcards
(145 cards)
1
Q
What is contained in yellow gas cylinders?
A
flammables or combustibles.
ref. MIL-STD-101B
2
Q
What is contained in grey gas cylinders?
A
Physically dangerous materials
ref. MIL-STD-101B
3
Q
Rubber seals on shock struts are designed for what?
A
To keep the piston surface clean.
A&P manual
To keep system sealed.
NAVAIR 01-1A-17
4
Q
What is the rivet diameter measured in?
AN470AD5-12
A
Diameter is measured in 32s of an inch.
this would be 5/32 wide, 12/16 in length.
5
Q
What is rivet length measured in?
AN470AD5-12
A
length is measured in 16ths of an inch
this would be 12/16ths
6
Q
What type of fire detector illuminates after a preset amount of heat is present?
A
Thermal switch. if temperature rises a preset amount in any one circuit the thermal switch closes and completes the circuit to indicate fire or high temp/overheat.
7
Q
What manual are air crew wings awarded with?
A
M1000.2, 4.A3
Enlisted Evaluations Accessions and Advancements.
8
Q
What manual are aircrew wings rescinded with?
A
M1000.2, 4.A3
Enlisted Evaluations Accessions and Advancements.
9
Q
An AN-AMT can receive wings IAW what manual?
A
M3710.1 g.8-2
10
Q
What type of barrier system for level 2 preservation?
A
Top cover, Strippable coating, and tape and barrier for level 2 and 1
NAVAIR 15-01-500
11
Q
How long is level 1 preservation good for?
A
Maximum of 90 days
NAVAIR 15-01-500
12
Q
If an aircraft is to remain idle for ____ days, preservation is required?
A
14 days or more
NAVAIR 15-01-500
13
Q
How many types of ice are there?
A
2
14
Q
What are the types of icing?
A
Rime and Clear
15
Q
What type of ice forms on a windshield during light rain?
A
Rime ice
A&P manual
16
Q
What is the rivet spacing requirement for a single row of rivets?
A
Never least than 4x the shank diameter
1-1A-8.1.1.7
17
Q
How long are fuel farm documents to be retained?
A
12 months
PG-85-00-170-A,7.2
18
Q
Ground support equipment shall be operated on the ramp IAW what manual?
A
NAVAIR 00-80T-96
19
Q
If PRIST (FSII) levels fall below what amount, do you need to call the CO?
A
If PRIST(FSII) falls below .07% by volume the CO must be notified. PG-85-00-170-A
20
Q
What size lettering for Aviators breathing oxygen?
A
2 inches high, 3inches wide, white band
M13520.1 C (ALSE) manual
21
Q
How long to inflate LRU-25/A crew raft?
A
30 seconds
M13520.1 C (ALSE) manual
22
Q
What system assigned material designators?
A
Uniform Material Movement and Issue Priority System
(UMMIPS) PG 85-00-110-A.6-5
23
Q
The LPU-27/PE is worn by who?
A
Rotary wing aircrew members trained in its use.
M13520.1C.2-28
24
Q
The LPU-26/p is worn by who?
A
Fixed wing aircrew members trained in its use.
M13520.1C.2-8
25
How many Peak Lumens for the distress strobe?
150,000 peak lumens
| 13520.1C.4-21
26
How long will the survivor locator transmit light?
it will operate for 8hrs using 1 candlepower
| M13520.1C 4.13
27
The MK79 signal kit uses what projector?
MK31 projector
| M13520.1C 4-21
28
Who approves flight syllabi?
CG-711
| M3710.1G
29
What manual lists the official Coast Guard mission programs?
CG pub1 pg 5
9 missions;
Search and Rescue, Environmental protection, Law enforcement, Ice operations, Aids to navigation, Boating safety, military readiness, CG reserve, CG auxiliary.
30
What is the maximum amount of flight time you can accumulate in 7 days?
50hrs
| M3710.1G 3-13
31
Grounding limits for blood donation?
200cc or more- 72hrs
| M6410.3A
32
How many hours for permanent AMS wings?
200hrs for rotary
400hrs for fixed wing
M3710.1G
33
*How long are completed flight syllabi retained?
Indefinite, not stated?
34
What initial training must an AMS complete?
CRM
| M3710.1G 8-3
35
*How often must you complete dunker training?
72 months
| M3710.1G 8-4
36
What must be completed if you don't fly for 6 months?
Stan Check
| M3710.1G 8-6
37
Hoist qualified personnel must hoist how often?
Once every 90 days.
| M3710.1G 8-22
38
Semiannual mins may be prorated if member is TAD in excess of how long?
30 days.
| M3710.1G 8-6
39
How many emergencies must a FM complete every semiannual period.?
2
| M3710.1G 8-22
40
How many secure voice HF ops must a MSO complete in every semiannual period?
2
| M3710.1G 8-28
41
Wet drills are designed to have personnel in the water for how long?
10 minutes
| M3710.1G 8-32
42
How much weight is in the vest during wet drills?
2 lbs
| M3710.1G 8-33
43
How often must the FEB meet?
Minimum Quarterly
| M3710.1G 8-40
44
How many training sessions must an instructor complete each semi?
3 instructor syllabus flights
| M3710.1G 8-30
45
How long does a unit training officer have to submit a letter after a member has lapsed.?
Within 30 days following the end of a period.
| M3710.1G 8-39
46
Blood and Urine are required after what types of mishaps?
Class A and B mishaps
| M5100.47A 3-3
47
What does RCM use as it database?
ACMS collects and stores information used in RCM.
| CGTO PG 85-00-10-A 1-1
48
What is the purpose of ACMS?
Managing Aircraft Maintenance.
| CGTO PG 85-00-10-A 1-1
49
Who designates QA's?
EO
| PG 85-00-110-A
50
Who designates UCPM?
EO.
| PG 85-00-60-A 2-3
51
How long is UCPM designated for?
2 years
| PG 85-00-60-a 2-4
52
Who is charged with inventory of aircraft due to transfer?
Material officer.
53
Who do you report excess property to?
Property officer.
54
What amount do you need 3 quotes?
```
when it is over the micro purchase threshold of;
2500 for services
3000 for supplies
2000 for construction.
M4200.13H 1-10
```
55
What is the simplified acquisitions procedure limit?
100,000
| M420013.H 9-1
56
At what percent do you test an aircraft flight control cable rated at 3500lbs?
60% of safe working load.
| NAVAIR 1-1A-8
57
How much wear is allowed on lifting slings?
1/3
| NAVAIR 17-1-114.1,500 pg 13
58
What system assigns units material designations?
Uniform Material Movement and Issue Priority System.
| PG 85-00-110A 6-5
59
Who is in charge of aviation training for aviation rates?
CG-41 or DCMS-81
| M13020.1G 6-1
60
How often is the GSE convention?
Annually
61
How long must a crew member be designated before they can receive and instructor qualification?
6 months
| M3710.1G 8-29
62
Who is the primary source for issuing an MSDS/ SDS?
Manufacturer.
| M16478.1B 3-1
63
What principle is used for fluid pressure?
Pascals law.
64
How does the taximan indicate he has command?
Holds one hand palm forward, motionless, high over head .
| PG 85-00-110 encl 4
65
what is the head design for a close tolerance bolt?
Triangle in middle.
| 1-1a-8 3-3
66
What designates drilled head and drilled shank?
H before dash number indicates drilled head and shank.
A after the dash number with H before dash number indicates drilled head only.
1-1A-8
67
What is the maximum wind for jacking aircraft outside?
15 knots
| PG 85-00-110-A 2-18
68
What does the PA stand for on the MSR?
Publication Audit.
| PG 85-00-10-A 5-1
69
What type of support vehicle requires a placard stating to 50 ft away from fueling?
Electric cart.
70
What is the distance for non essential equipment securing during fueling operations?
50ft.
71
How soon before a hot gas must you notify the fire dept.?
15 minutes
| PG 85-00-170-A 8-7
72
What type of fire extinguisher for a solvent fire?
Carbon dioxide.
| PG 85-00-110 2-1
73
What is the draw pull on a tow bar?
10x
74
How often is the NT-4 tow bar inspected?
Every 6 months
| MSR
75
What are ship tie downs rated to?
10,000 lbs.
76
how are type 1 parts ordered?
Through routine message.
| PG 85-00-110-A 6-4
77
In what instant do you issue a message for an engine?
Engines removed solely for routine inspection need not be reported unless difficulties beyond unit capabilities are encountered.
PG 85-00-110-A 6-4
78
*What determines the strength of a riveted joint?
Shear strength ?
79
On a drawing what does a line with long and short dashes indicate? ----- -- ------- -- -------- -- --------
centerlines are made up with alternating long and short dashes
AP drawings 2-16
80
What is detailed view of a part with manufacturer notes on an aircraft drawing called?
Detailed Drawing.
| AP 2-2
81
What strength must an aircraft repair have?
Equal to or greater than the original strength.
| 1-1A-1
82
How do you log 13.3 hours on a AFTO 781J?
Manual entry or computer spreadsheet.
| PG 85-00-110-A 4-2
83
What manual do you use to fill out an AFTO 103?
AFTO 00-25-4
| PG 85-00-110-4 4-12
84
What is the high end torque value on hardware used for?
Cotter pin alignment.
| 1-1A-8 16-28
85
What manual do you use to extend engine maintenance.?
13020.1G 5-3
86
Can you extend LCF items?
No extensions are authorized for low cycle fatigue limits on aircraft components.
13020.1G 5-3
87
Who can extend the life fatigue limits on aircraft components?
no one can
88
What manual is used for respiratory protection?
5100.47
| Safety and environmental health manual
89
What manual is used specialty traing schools?
M1500.10D
| Performance, Training and Educational Manual
90
What is the PH level for the wash rack?
6-8 pH
| GS MPC 159001.0
91
Who can frock enlisted personnel?
Commandant authority.
| M1000.2 3.A.31
92
How many parts are on an electrical connector?
2
Receptacle /Jack
plug
NAVAIR 1-1A-505-1
93
What is the fixed part of an electrical connector?
Receptacle /Jack
| NAVAIR 1-1A-505-1
94
How long after a flight can you pressure check tires?
2 hours
3 hours in hot weather.
AMT2 Airframe system Mx
95
How many forces are at work on an aircraft in flight?
4
1. Lift
2. Weight
3. Thrust
4. Drag
FAA- General
96
What does the ILS system use for its vertical reference?
Vertical- Glideslope
Horizontal- left right on course
1H-60T-2-8-V2.34-00-00
97
How often is MRM training required?
Biennially (2years)
98
If you have 1000psi of nitrogen and add 3000psi hydraulics, what happens t the nitrogen pressure?
The nitrogen compresses to 3000psi.
| FAA airframe 2
99
What s the audible distance for a Whistle?
1000 yards.
| 13520.1C ALSE
100
Signal Mirror?
?
101
Strobe?
?
102
What do you do t correct a newly installed twisted o-ring?
Gently roll it to remove any twists
| NAVAIR 1-1A-17, 15
103
How is cabin pressure maintained?
Normal operations-isobaric mode, high altitude-constant differential mode. Cabin pressure controller is the device used.
outflow valve?
FAAvol 2
104
During unit to unit transfer. who is the reporting custodian?
Gaining unit.
| PG 85-00-160-A. 3-1
105
Who authorizes operational transfers?
CG-711 or the operational commander.
| PG 85-00-160-A. 2-1
106
What is the dollar amount for type 4 material?
Avionics- $800 or more
| PG 85-00-110-A.
107
Where can you find the MDL in EAL?
ALMIS-DSS web reports-Unit Mx reports.
| PG 85-00-110-A.
108
How many types of fuselage are there?
2- Truss and monocoque
| FAA airframe 1,1-8
109
What form is used to report discreps with DOD material?
SF-368-PQDR.
| PG 85-00-110-A. 4-12
110
What percent of mishaps are MX related?
20% for comercial, DOD, CG are similar.
| 1320.1G. 6-4
111
What percent of hardware failure is due to fatigue?
Fatigue failure account for 75% of fastener failures.
| 1-1A-8
112
How often are AVGFET rectified?
certification is valid for one year.
113
What manual is used for confined space safety?
M5100.47A
| Safety and Environmental Health Manual
114
What do you do with a TCTO kit for an A/C during a ferry flight?
It will accompany the A/C on ferry flight until it is incorporated.
PG 85-00-110A. 6-7
115
What is a TCTO labeled SPAR?
TCTO kits for spare components in lieu of aircraft/engine serial number.
PG 85-00-110A. 6-7
116
What is required if you fly for 6 months?
STAN check for re-designation.
| 3710.1G 8-5
117
Who reviews rate performance qualifications?
DCMS-81, Rating force MasterChief, and Forcecom.
| 1320.1G. 6-1
118
How often is a unit of survey required?
At least annually given by the direction of the CO.
| M5100.47A. 20-17
119
What funds are for GSE repair?
Below 3K, Unit funds/ AFC 30
Above 3K ALC
PG 85-00-140, Aero support equipment.
120
*When being relieved as a shop chief, how long do you have to complete an inventory?
30 days?
121
Who authorizes prototype installation on aircraft?
CG-41
| 13020.1G 1-6
122
*What is CG-41?
?
123
* What is CG-711?
?
124
What is the commandant policy on sexual harassment?
Zero tolerance
| M5350.4 civil rights manual
125
An "X" in CGBI indicates what?
Requirement is overdue
| EPME 3.D.02
126
How much time her week must the CO give you to work out?
180 minutes / 3hrs per week
| M6200.1B, 4-3
127
What year did the Navy adopt theChief rank?
April 1 1893
| EPME-4-7.01
128
What is an E-7 in the Air force?
Master Sergeant.
| EPME 4.B.01
129
What is one mission under the role of Stewardship?
Ice Ops, ATON, Living Marine Resource, Marine Environmental Protection, Fisheries.
EPME 3.B.01
130
How many inactive days per year for CG SELRES members?
48 inactive.
| 12 active.
131
BAH is based on what?
Grade, Location and Dependency Status.
| EPME 3.D.03
132
Who saved 10 people off the Priscilla in 1899?
Ramus S. Midget
| EPME 4-5.01K
133
What type of discharge is under honorable conditions?
General Discharge.
| EPME 3.C.04
134
What article give you the right to remain silent?
Article 31 of UCMJ
| EPME 4.C.02
135
What is the max bulk for mens hair?
1.5 inches from scalp.
| EPME 8-7.01P
136
You will not be allowed to advance with a mark of what?
2 or below
137
How does the Rating Force Master Chief communicate with the field?
Force notes, Filed visits, and direct contact with individual members.
EPME 4.F.03
138
What is ICS?
Incident Command System: Provides command structure for emergency response.
EPME 4.G.05
139
*What units are assigned a substance abuse specialist?
?
140
When are special marks required?
Transfer, Advancement, Change in rate, Discipline, Probation, Reduction,.
M1000.2
141
*What is not and alcohol incident?
?
142
What form is the award recommendation?
CG-1650
| EPME 10-6.03P
143
What mark does not get a numerical value?
Conduct,
| 3788B
144
When ws th eCG assigned to the Navy for the first time?
WW1, April 1917
145
How many hours per day for EMI?
2 or less
| EPME 9-6.01-K
