2018

Question 1

Location of #1 overheat sensor on a 225 Honda outboard?

Answer 1

Port side top of manifold

Question 2

P100 discharge valve size?

Answer 2

2-1/2” and 3”

Question 3

What is the max thickness a males hair can be from the scalp?

Answer 3

1-1/2”

Question 4

What lubricates the lineshaft bearing?

Answer 4

Oil

Question 5

How is air that is delivered to a room measured?

Answer 5

CFM (Cubic Feet Per Minute)

Question 6

What happens to a Teflon seal if petroleum products gets on it?

Answer 6

Leaks

Question 7

How to decide what type of pipe?

Answer 7

Use

Question 8

What type of metal is non-ferrous?

Answer 8

Brass

Question 9

What part of the tag out log is for inactive tags?

Answer 9

Section 4

Question 10

How much air can be in a receiver?

Answer 10

600 psi

Question 11

After an oil and filter change allow how any hours before taking a sample?

Answer 11

25

Question 12

Pre constructed hoses have a shelf life of how many years?

Answer 12

10

Question 13

What must be marked on a shore-tie breaker?

Answer 13

Phase, Voltage, Capacity

Question 14

Testing a load at 125% is what type of test?

Answer 14

Dynamic load test

Question 15

Hose size of -16 has an inside diameter of?

Answer 15

1”

Question 16

Hose size of -10 has an inside diameter of?

Answer 16

5/8”

Question 17

What is a pressure-transmitting device that restricts the rate of fluid flow to a pressure-sensing instrument and, as a result the rate of pressure change?

Answer 17

Pressure snubbers

Question 18

You secure the P6 pump bags with?

Answer 18

Rubber bands

Question 19

What fuel has a flash point of 100 deg F?

Answer 19

JP-8

Question 20

The contractor shall start cleaning the hull within how many hours of a haul out?

Answer 20

4 hours

Question 21

What is not authorized for women figure nails?

Answer 21

Not multi colored, not decorative, not longer than ¼”

Question 22

What is not authorized on ODU while participating in ceremonial details, while in formation, or while performing unit functions?

Answer 22

Cell phone

Question 23

While wearing SDB your shirt collar shows at least how much above coat collar at the center back of the coat?

Answer 23

¼”-1/2”

Question 24

What separates large particulates and sand from water on a NSC R/O?

Answer 24

Media filter

Question 25

OWS works off of what two principles?

Answer 25

Gravity separator and coalescer

Question 26

Where can you discharge OWS?

Answer 26

Overboard 15 PPM, greater than 12nm

Question 27

What element do anti friction bearings have?

Answer 27

Rolling element

Question 28

What position should throttle be in on outboard engine when doing a compression check?

Answer 28

Full

Question 29

Why do you pull top plug on lower unit?

Answer 29

Check level

Question 30

How many separate queries in FEDLOG?

Answer 30

8

Question 31

What query to use if you’re unsure of data in FEDLOG?

Answer 31

Find it

Question 32

When do you use an orange out of calibration label?

Answer 32

If deviation is small and consistent

Question 33

Excessive L/O consumption after overhaul caused by what?

Answer 33

excessive blow-by, which will cause the rings to stick and clog the ring lands with carbon.

Question 34

Circumferential grooving on babbitted bearing caused by what?

Answer 34

Dirt and abrasive material

Question 35

How long does PICO have to keep records?

Answer 35

3 years plus current year

Question 36

When do you conduct a wall to wall?

Answer 36

Units that fail two consecutive random samples must complete a wall-to-wall inventory within 20days of the completion date for the last physical inventory.

Question 37

How do alternators work?

Answer 37

Turning of the magnet over the stator creates electricity

Question 38

Duplex bourbon tube gauge measures pressure difference across what?

Answer 38

Strainers

Question 39

How many over heat sensors on a BF-225 outboard?

Answer 39

2

Question 40

How many vendors do you need to get a quote from?

Answer 40

3

Question 41

Weight test 125% of WLL?

Answer 41

Dynamic

Question 42

Where do you have pressure relief valve on positive displacement pump?

Answer 42

Discharge

Question 43

What kind of motion is generated by a hydraulic ram?

Answer 43

Linear motion

Question 44

What form for booking someone?

Answer 44

4910

Question 45

When fighting a fire when protection what should be done with the door?

Answer 45

establish a Smoke Control Zone (SCZ)* by closing those hatches and doors immediately adjacent to the access to the affected space.

Question 46

P6 discharge rate?

Answer 46

250 GPM at 12’

Question 47

Form number for boat inspection report?

Answer 47

CG3022

Question 48

What are 2 types of gate valves?

Answer 48

Parallel and wedge

Question 49

What does a member do when encountering a fire?

Answer 49

Initiate the alarm