95-96 Simon Log Book Flashcards
(100 cards)
1
Q
Simon-LTI is equipped with a __________-controlled engine & transmission.
A
Computer
2
Q
95-96 Simon max top of tiller cab height ____
A
11’8”
3
Q
95-96 Simon height top of cab roof ___
A
10’5”
4
Q
95-96 Simon cab full tilt position
A
16’2”
5
Q
95-96 Simon length ___
A
54’10”
6
Q
95-96 Simon width (including mirrors) ___
A
10’0”
7
Q
GVWR (Gross Vehicle Weight Rating) ____
A
65,500
8
Q
GAWR (Gross Axle Weight Rating) Front Axel _____
A
20,000
9
Q
GAWR (Gross Axle Weight Rating) Rear Axle ____
A
24,000
10
Q
GAWR (Gross Axle Weight Rating) Tiller Axle _____
A
21,500
11
Q
Apparatus Average Weight (Fully Loaded Including Personnel) ______
A
58,910 lbs
12
Q
Apparatus Average Weight (Front Axle) ________ _________
A
16,150 (95) 15,650 lbs (96)
13
Q
Apparatus Average Weight (Rear Axle) ______ _________
A
21,330 (95). 22,550 lbs (96)
14
Q
Apparatus Average Weight (Tiller Axle) ________ _________
A
21,280 (95). 20,710 lbs (96)
15
Q
Ground Jack Spread - Fully Deployed ______
A
16 Feet
16
Q
1995 & 1996 Cummins ______ BHP @ _____ RPM
A
460 1600
17
Q
1995 & 1996 Cummins ____ Liter, N- __-___E
A
14.0 14-460
18
Q
1995 & 1996 Cummins; Engine Oil Pressure Normal Operating Range; ___ psi min @ idle ___-___ psi min @ rated
A
10 35-45
19
Q
1995 & 1996 Cummins; Engine Coolant Temperature Normal Operating Range; ___to___°F Max ___°F
Normal Operating Range ____to____RPM
A
180-200°F 220°F
1200-1600°RPM
20
Q
1996 Detroit Diesel ___ BHP ___ Liter Series ___
A
470 12.7 60
21
Q
1996 Detroit Diesel; Engine Oil Pressure Normal Operating Range ___psi min @idle ___psi min @ rated.
A
12, 50
22
Q
1996 Detroit Diesel; Engine Coolant Temperature ___to___°F Max. ___°F
A
160 to 210°F, 230°F
23
Q
1996 Detroit Diesel; Normal Operating Range ____to____RPM
A
1200 to 1800
24
Q
Apparatus Normal System Voltage
___to___ Volts
A
12.9 to 14.4
25
Transmission Fluid Temperature ___to___°F (NE) & ___to___°F (O)
140 to 220°F & 160 to 200
26
Air Brake Normal Operating Range ___psi to ___psi
90 to 120
27
Fuel Tank Capacity ___ Gallons
50
28
Fast Idle ____-____ RPM
1500-1600
29
Emergency Power Unit (EPU) Pump ___ GPM @ ____ PSI
1.5, 2000
30
ONAN GENERATOR OPERATING RANGES; Engine oil pressure ___-___ PSI @ Oper Temp
28-64
31
ONAN GENERATOR OPERATING RANGES; Engine Coolant Temperature ___° to ___° F
160 to 190
32
ONAN GENERATOR OPERATING RANGES; Output ___ kW
7.5
33
ONAN GENERATOR OPERATING RANGES; DC Voltmeter ___-___ Volts
12.5 - 15
34
HYDRAULIC SYSTEM CAPACITIES; Oi Reservoir Capacity ___ Gallons
40
35
HYDRAULIC SYSTEM CAPACITIES; Hydraulic Pump Capacity ___ GPM
20
36
HYDRAULIC SYSTEM CAPACITIES; Max System Pressure ____ PSI
2800
37
HYDRAULIC SYSTEM CAPACITIES; Outrigger Relief Valve Setting ____PSI
2000
38
HYDRAULIC SYSTEM CAPACITIES; Max Hoist Pressure ____PSI
2800
39
HYDRAULIC SYSTEM CAPACITIES; Rotate Max Pressure ____PSI
1500
40
HYDRAULIC SYSTEM CAPACITIES; Extend/Retract Max Pressure ____PSI
2000
41
HYDRAULIC SYSTEM CAPACITIES; Lowering Into Cradle Max Pressure ____PSI
800
42
HYDRAULIC SYSTEM CAPACITIES; Ground Jack Deployed Light Activation ____PSI
800
43
AERIAL LADDER DIMENSIONS; Elevation ___° to +___°
-4° to +75°
44
AERIAL LADDER DIMENSIONS; Retracted ____ Feet
31.8
45
AERIAL LADDER DIMENSIONS; Extended ___ Feet
94
46
AERIAL LADDER DIMENSIONS; Elevated Height ___ Feet
100
47
AERIAL LADDER DIMENSIONS; Sections ___
4
48
High Water Temp. Light: illuminates when coolant rises above ___
220
49
Approaching Jackknife Indicator Light: illuminates when tractor and trailer are at ___° & ___° angle
65° 80°
50
Low Air Pressure Indicator Light: illuminates when the air psi falls below ___ psi
60
51
Air Cleaner Restriction Guage: max at FULL LOAD and governed rpm is ___in. H20 & at NO-LOAD and governed rpm is ___in. H20
25 & 12
52
Low Engine Oil PSI Light: illuminates when oil falls below ___ psi.
3
53
Battery Master Power: MDT draws ___ to___ amps even when battery master switch is turned off.
7 to 8
54
High Idle Switch: raises engine rpm to approx. ____RPM
1000
55
Tiller Cab Heater Temp. Control: used o adjust temp. In tiller cab
Low ____ BTU
Medium ____ BTU
High ____ BTU
2900
4100
6150
56
1996 Detroit Diesel Series 60 Engine; ___ cylinder & ____ cubic inches
6 & 774
57
1996 Detroit Diesel Series 60 Engine; _____” Bore and a ____” stroke.
5.12” & 6.30”
58
1996 Detroit Diesel Series 60 Engine; compression ratio of ______ to ___
15.0 to 1
59
1996 Detroit Diesel Series 60 Engine; torque _____-ft lbs at ___ RPM
1550 at 1200
60
1996 Detroit Diesel Series 60 Engine; Horsepower ___ at ____ RPM
470 at 2100
61
1996 Detroit Diesel Series 60 Engine; operating range is ____ RPM to ____ RPM
1200 to 1800
62
1996 Detroit Diesel Series 60 Engine; can run an additional ___% higher than maximum operating range.
7
63
1996 Detroit Diesel Series 60 Engine; designated to run @ lower RPM with best fuel economy between ____ to ____
1200 to 1800
64
1995 & 1996 Cummins N-14-460E Diesel Engine: ___ cylinder, ___ cubic inches
6, 855
65
1995 & 1996 Cummins N-14-460E Diesel Engine: compression ratio of ____ to ___
16.3 to 1
66
1995 & 1996 Cummins N-14-460E Diesel Engine: ___” bore and a __” stroke
5 1/2 & 6
67
1995 & 1996 Cummins N-14-460E Diesel Engine: torque, ____ at ____ RPM
1550 at 1200
68
1995 & 1996 Cummins N-14-460E Diesel Engine: horsepower ___ at ____ RPM
460 at 1600
69
1995 & 1996 Cummins N-14-460E Diesel Engine: can run an additional ___% higher than max operating range.
7
70
1995 & 1996 Cummins N-14-460E Diesel Engine: Best fuel economy between ____ - ____ RPM
1200 - 1600
71
Starting Apparatus; if engine start within ___ seconds, release starter button and allow starter to cool for ___ seconds before trying again. If it fails to start after ___ attempts, inspect to determine cause.
15 & 15, 4
72
OIL PRESSURE; if there is no oil pressure within ___ to ___ seconds. Stop the engine and check lubrication system.
10 to 15
73
OIL PRESSURE; Oil pressure should not fall below ___ psi at ____ - RPM Detroit & ___ PSI at _____ RPM Cummins.
28 @ 1800 & 35 @1200
74
IDLING; After ___ min engage ______ _____
5 High Idle
75
TURBO: Try not to shut down unless coolant is ___°F or less.
195
76
CAB TILT PROCEDURE: Full tilt position is approximately ___ °
50
77
LOWERING CAB: Lower position until cab has settled on supports & continue to hold for another ___ seconds to ensure cab locks fully engage.
5
78
SERVICE BRAKE ADJUSTMENT CHECK PROCEDURE; If position measured exceeds __” on the ear or the front brakes, the brakes are out of adjustment and require immediate attention.
2
79
BRAKE LINING INSPECTION: Lining should be no less than ___ of an inch on either pad or less than steel backing plate.
1/4
80
BRAKE CHAMBER MANUAL RELEASE; ___ “ diameter bolt located at end of spring brake chamber utilizing ___” box end wrench or socket.
1/2 & 3/4
81
JUMP STARTING BATTERIES: To avoid damage, voltage supplied to a vehicles electrical system must not exceed ____ volts.
16.0
82
JUMP STARTING BATTERIES: Connect one end of the second jumper cable to the negative terminal on the booster battery, and the other end to the frame of the disabled vehicle at least ___ “ away form battery.
18
83
1995-1996 Simon LTI: Information contained in this operation manual will assist in _________ ________ _______
Troubleshooting
Operation
Maintenance
84
1995-1996 Simon LTI: Divided into ___ sections
5
85
1995-1996 Simon LTI: ___ types of headings _______ ______ ______
3
Danger
Caution
Note
86
1995-1996 Simon LTI: when requesting additional Apparatus info contact ______ @ 213-485-______
S&M 6111
87
Simon-LTI is equipped with a computer-controlled engine & transmission. Each controlled by their own ECU’s (Electronic Control Units). Each incorporates its own individual ________ ________ ________
Program
Diagnostic Capabilities
Safety Features
88
1995-1996 Simon LTI: What type of communication system is used?
David Clark
89
1995-1996 Simon LTI: what type of starter is used?
AC/Delco
90
1995-1996 Simon LTI: To activate the high beams, pull the lever _________ you until it “clicks”.
Towards
91
1995-1996 Simon LTI: the Detroit Diesel engine is called?
Series 60 - DDEC (Detroit Diesel Electronic control)
92
1995-1996 Simon LTI: Each outer windshield wiper switch has how many speeds?
2 (High & Low)
93
1995-1996 Simon LTI: The Engine Ignition switch is a _______
ROCKER
94
1995-1996 Simon LTI: The Radio Switch controls the 800 radios & MDT & is located in the compartment just below?
Captain Seat
95
1995-1996 Simon LTI: The ECU’s means?
Electronic Control Units
96
1995-1996 Simon LTI: All 8 tires are rated ___?
J
97
1995-1996 Simon LTI: When checking batteries, you should not _______ _____
Green Eye
98
1995-1996 Simon LTI: Wear safety goggle & _______ _______ when working around batteries?
Protective Clothing
99
1995-1996 Simon LTI: When jumping the battery, the vehicle with the good battery should be ran at what RPM?
1,000 to 1,500
100
When checking brake travel, always be aware of the location of the __________________ and be sure to move away when the driver releases pressure on the brake pedal.
Brake relay exhaust port
