Rigs Flashcards
Becker:
Height
10’ 1”
Becker:
Weight
42,000 lbs
Becker:
Width
8’ 8”
9’ 8” With Mirrors
Becker:
Length
32’ 9”
Becker:
Foam Tank Size
30 Gallons
Becker:
Oil Amount
38 qts
Becker:
Transmission Fluid
47 qts
Becker:
Fuel
50 Gallons Diesel
Becker:
Turning Radius
71’ 10”
Becker:
What Is the Req’d Air Pressure for the Low Air Pressure Light and Buzzer to Turn Off?
60 psi Front and Rear
Becker:
Crank Engine ____ seconds
Then Wait ____seconds to Attempt Again.
15 seconds
60 seconds
Becker:
How Many Speeds?
Total Speeds is 6
5 Forward
1 Reverse
Becker:
How do you Attain 5th Gear?
Mode Button
Becker:
What Lights Turn Off When Rig is Parked?
White Flashing Lights
Becker:
Load Manage Sequence ___ to ___.
1 to 8
Becker:
After ___ minutes, Electrical Loads will Shed.
1 minute
Becker:
Loads Will Remain off for ____ min and
Until Unshed Voltage is Achieved for ___ min.
5 minutes
1 minute
Becker:
What has to be Set for the Loads to Shed?
Parking Brake
Becker:
Don’t Run the Primer Longer Than __sec.
The Pump Should Prime Within __-__sec.
60 seconds
15-45 seconds
Becker:
Where Can you View the Oil Level for the Primer Pump?
Passenger Pump Panel
Becker:
List the Two Modes of Operation for the
Electronic Fire Commander.
RPM and Pressure
Becker:
How do you Enter the Programming Menu?
Hold ‘mode’ and ‘menu’ Simultaneously.
Becker:
_____ Exits and Saves Changes.
____ Exits Without Saving Changes.
Idle
Mode
Becker:
RPM Increase and Decrease in ____ Increments.
Whereas Pressure (psi) mode Increases and Decreases in ____ Increments.
25 RPM
4 psi
E1 Cyclone:
Height
9’
E1 Cyclone:
Weight
38,600 lbs
E1 Cyclone:
Width
8’
E1 Cyclone:
Length
30’ 6”
E1 Cyclone:
Oil Capacity
32 qts of 30W
E1 Cyclone:
Trans Fluid Capacity
33 qts of Dex
E1 Cyclone:
Fuel Consumption__-__Gallons Per Hour
5-6 Gallons Per Hour
E1 Cyclone:
Primer Oil
4 qts of 30W
E1 Cyclone:
Power Steering Fluid
10W40
E1 Cyclone:
5 Hose Loads
1100’ of 4”
300’ of 1 3/4”
200’ of 2”
200’ of 1”
Additional 200’ of 2 1/2” (not preconnected)
E1 Cyclone:
What is Adequate Oil Pressure__-__psi
Idle @__-__psi
40-60 psi
(5-10psi @ idle)
E1 Cyclone:
What is the Normal Air Pressure to Operate the Parking Brake__-__psi
90-120 psi
E1 Cyclone:
What is the Normal Operating Temperature__-__F
160-210 F
E1 Cyclone:
Crank __-__ sec Wait ___ sec
Attempt to Start __-__ Times.
15-20 sec
30 sec
3-4 times
E1 Cyclone:
Idle Engine __-__minutes After Stopping.
3-5 minutes
E1 Cyclone:
Telma Retarder has ___ Stages and
Supplies Up to ___% of Stopping Force?
4
85%
E1 Cyclone:
What does the Speedometer Show in Pump Gear__-__mph
25-35 mph
E1 Cyclone:
How Many Large Discharges?
Total of 5
Discharge #5 is 3” stortz
E1 Cyclone:
The Gated Relief on the Intake is Set @ __or__psi
150 or 250 psi
E1 Cyclone:
There are ____ Pre Connects.
Total is 3 PreConnects:
Front 100-150’ of 1 3/4”
Right 150-200’ of 2”
Rear 200’ of 1 3/4”
E1 Cyclone:
Where is the Manual Pump Shift located?
There is NO Manual Pump Shift on the E1 Cyclone.
E1 Cyclone:
What do you Pump (psi) with Foam Operations?
200 psi
E1 Cyclone:
What % Foam Mix?
1%, 2%, 3%, 6%
E1 Cyclone:
Flush The Foam From All Discharges at ____ psi
100 psi
E1 Teleboom:
Height
12’
E1 Teleboom:
Weight
43,000 lbs
E1 Teleboom:
Width
8’
9’ 10” With Stabilizers
E1 Teleboom:
Length
32’
E1 Teleboom:
Oil
32 qts of 30W
E1 Teleboom:
Transmission Fluid
33 qts of Dextron II
E1 Teleboom:
Primer Fluid
6 qts of 30W
E1 Teleboom:
Power Steering Fluid
10W40
E1 Teleboom:
Ladders
50’ Tele-boom
24’ Ext
14’ Roof
10’ Attic
E1 Teleboom:
Turning Radius__-__
34’-37’
E1 Teleboom:
Waterway Nozzle Capability___-___GPM
300-1000 GPM
E1 Teleboom:
Tire Pressures
Front 110 psi
Rear 115 psi
E1 Teleboom:
Hose Loads
Total is 4 Hose Loads:
1100’ of 4”
300’ of 1 3/4”
200’ of 2”
200’ of 1”
E1 Teleboom:
What Is the Oil Pressure After Starting__-__psi
40-60 psi
E1 Teleboom:
Idle to Increase Air Pressure to __-__psi
to Release the Parking Brake.
90-120 psi
E1 Teleboom:
Normal Operating Temperature___-___ F
160-210 F
E1 Teleboom:
Crank for __-__ sec Wait ___ sec
Attempt __-__ Times.
15-20 sec
30 sec
3-4 Attempts
E1 Teleboom:
Allow the Engine to Idle __-__minutes Before Stopping.
3-5 minutes
E1 Teleboom:
Telma is in ___ Position Before Brake is Applied.
Position 3
E1 Teleboom:
What Keeps the Pump Throttle From Working?
Park Brake Not Engaged
E1 Teleboom:
Wait __-__ sec to Shift the Pump Shift From Neutral to Pump.
2-3 seconds.
E1 Teleboom:
Speedometer Will Show __-__mph in Pump Gear.
25-35 mph
E1 Teleboom:
Don’t Engage the PTO When ____.
The Water Pump Is In Operation
E1 Teleboom:
List Two Reasons for No Throttle In the Cab.
- Pump Is In
2. Check Engine Light Is Pushed In.
E1 Teleboom:
List Three Reasons There is No Throttle at the Pump Panel.
- Pump Not Engaged
- Check Eng Light is Pushed In
- Park Brake Not Engaged
E1 Teleboom:
Fast Idil
1200 RPM
E1 Teleboom:
List Three Reasons for the Fast Idle Not Working.
- No Fast Idle if Park Brake Isn’t
- No Fast Idle if Pump Is
- No Fast Idle if Not in Neutral
E1 Teleboom:
Pump ___psi for 1000 gpm
180 psi
E1 Teleboom:
Don’t Operate On Grades Greater Than ___%.
6%