06/09 American LaFrance LTI Logbook Flashcards
(190 cards)
1
Q
What 5 sections is the logbook divided into?
A
Introduction Driving and controls Aerial operations Records Maintenance
2
Q
What are the 3 types of headings in the logbook?
A
Danger - if not followed correctly can result in injury or death
Caution - if not strictly observed can cause damage or destruction to equipment
Notes - essential to highlight
3
Q
What 4 things are the 06 and 09 trucks equipped with?
A
Computer controlled engine
Computer controlled transmission
ABS
Electrical load management system
4
Q
The 06 and 09 trucks components have their own?
A
Electronic control units (ECU)
5
Q
Each components ECU on the 06 and 09 trucks incorporate what 3 things individually?
A
Program
Diagnostic capabilities
Safety features
6
Q
What are the shop numbers for the 2006 trucks?
A
60691-60704
7
Q
What are the shop numbers for the 2009 trucks?
A
60736-60739
8
Q
What is the height of the tiller cab for the 2006 trucks?
A
11’1”
9
Q
What is the height of the tiller cab for the 2009 trucks?
A
11’3”
10
Q
What is the length of the 2006 trucks?
A
55’2”
11
Q
What is the length of the 2009 truck?
A
54’6”
12
Q
What is the height of the front cab fully tilted for the 06 and 09 truck?
A
15’6”
13
Q
What is the height of the front cab for the 06 and 09 truck?
A
10’
14
Q
What is the width of the 06 and 09 trucks mirror to mirror?
A
9’5”
15
Q
What is the gross vehicle weight rating (GVWR) of the 06 and 09 trucks?
A
65,500 pounds
16
Q
What is the jack spread for the 06 and 09 trucks?
A
14 feet
17
Q
What is the actual weight of the 06 and 09 trucks?
A
60,090
18
Q
What is gross axle weight rating of the front axle for the 06 and 09 trucks?
A
20,000
19
Q
What is the gross axle weight rating of the rear axle for the 06 and 09 trucks?
A
24,000
19
Q
What is gross axle weight rating of the tiller axle for the 06 and 09 trucks?
A
21,500
20
Q
What is the average weight of the front axle for the 06 and 09 trucks?
A
15,910
21
Q
What is the average weight of the rear axle for the 06 and 09 trucks?
A
22,370
22
Q
What is the average weight of the tiller axle for the 06 and 09 trucks?
A
21,810
23
Q
What is the normal system voltage range for the 06 and 09 trucks?
A
12.9-14.4 volts
24
What is normal oil pressure operating range for the 06 and 09 trucks?
10 psi @ idle, 30-45 psi @ rated
25
What is the normal temperature operating range for the 06 and 09 trucks?
190-208, 219 max
26
At what temperature does the fan clutch engage for the 06-09 trucks?
208 (06 and 09)
| At idle with parking brake set (09)
27
What is the transmission normal temperature range for the 06 and 09 trucks?
160-200
28
What is the normal air brake system range for the 06 and 09 trucks?
90-120 psi
29
What is the fuel capacity for the 06 and 09 trucks?
65 gallons
30
What is fast idle set at?
1500-1600 rpm
31
What is the rating for the EPU pump?
1.5 gpm @ 2000 psi
32
What is the engine oil pressure for the Onan?
28-64 psi @ normal operating temp
33
What is the coolant temperature for the Onan?
160-195 degrees
34
What is wattage output of the Onan?
7.5 kw
35
What is the DC voltmeter range for the Onan?
12.5-15 volts
36
What kind of engine do the 06 and 09 trucks have?
Caterpillar 525 BHP, 12.5 liter, C-13 electronic control
37
What kind of transmission do the 06 and 09 trucks have?
Allison HD 4560P 5 speed automatic world transmission
38
What kind of gear box does the 06 and 09 have?
TRW Model TAS 85 integral power steering gear box
39
What kind of power steering pumps do the 06 and 09 have for the front and tiller axles?
Front-vickers V20F-1D
Tiller-vickers V20F, C11 and C13
40
What kind of front axle do the 06 and 09 trucks have?
Rockwell F943 easy steer
41
What kind of rear axle do the 06 and 09 trucks have?
Rockwell RS23-180 drive axle
43
What is the gear ratio of the rear axle for the 06 and 09 trucks?
5.38:1
43
What kind of tiller axle do the 06 and 09 trucks have?
Rockwell FL941 easy steer
45
What type of air disc brakes are on the front, rear, and tiller axles for the 2006 truck?
Rockwell air disc brakes
45
What type of air disc brakes are on the front, rear and tiller axles for the 2009 truck?
Meritor EX 225
46
What kind of ABS system do the 06 and 09 trucks have?
Rockwell WABCO ABS
47
What kind of air brake system components do the 06 and 09 have?
Bendix
48
What kind of brake retarder do the 06 and 09 trucks have?
Jacobs engine brake
49
What kind of driveline U joints do the 06 and 09 trucks have?
Spicer 1810
50
What kind of alternator do the 06 and 09 have?
Leece Neville 320 amp pad mount alternator
51
What kind of batteries do the 06 and 09 trucks have?
AC Delco 31-900CT 12V maintenance free batteries
52
What kind of starter motor do the 06 and 09 trucks have?
AC Delco MT 42 type 400 12v starter motor
53
What kind of communication system does the 06 and 09 have?
Sigtronics
54
What kind of electrical load management system does the 06 and 09 truck have?
Class one
55
What kind of emergency lighting do the 06 and 09 trucks have?
Whelen
56
What size tire for the front axles of the 06 and 09 trucks?
Michellin 385/65R 22.5
57
What size tire do the rear axles have for the 06 and 09 trucks?
12R 22.5
58
What size tire do the tiller axles have for the 06 and 09 trucks?
425/65R 22.5
59
When does the voltage monitor alarm activate for the 2009 truck and will not deactivate until voltage increases by 1 volt?
When electrical voltage drops below 11.8 volts
60
What does the battery charger switch do?
Activates on board battery charger
61
What is the cab safety lock release cable do for the 06 and 09 trucks?
Used to release cab tilt ram safety lock
Pull cable to raise safety lock above the cab tilt ram before lowering cab
62
Where is the radio switch to shut off the 800/UHF/VHF radios and MDC located?
Compartment behind apparatus operators seat
Turns off radios and MDC, off position when black flag in UP position
63
Where is the engine diagnostic plug located on the 06 and 09 trucks and is used to connect computer to diagnose engine?
Near the steering wheel tilt control
64
What does the compartment door lock switch do?
Used to lock and unlock compartment doors on trailer
65
How many amps does the MDT draw even with battery switch off?
7-8 amps
66
What is high idle set at?
1000 rpm
67
At what angles does the jackknife indicator light illuminate for the 06 and 09 trucks?
65 and 80
68
What will the monometer read in mercury in inches (H20) and max restriction at full load?
25 inches H20
69
What will the monometer read in mercury in inches (H20) and max restriction at no load?
15 in H20
70
What does the cab air recirculating switch do?
Opens or closes all vents to outside air for the purpose of cab ventilation
71
What does the air condition activation switch do?
Switch enables AC compressor, must be turned on for the temperature control to regulate the AC
72
What does the traffic advisor do?
Activates the traffic advisor lights at the rear of the tiller cab
73
What does the transmission t-handle selector do and includes access to transmission diagnostic codes and transmission fluid checks?
Allows selection of automatic and manual control of reverse, neutral and forward speeds
74
When does the aerial not stowed light activate?
Illuminates when the aerial is not stowed for travel
75
When does the cab door ajar light activate?
Illuminates when a tractor cab door is open
76
When does the accessories up indicator light activate?
Illuminates when aerial ladder is not bedded
77
When does the body door ajar light activate?
Illuminates when any trailer body door is open
78
What is OPT switch for?
Spare switch for future use
79
What does override switch do on the captains side in the cab?
Deactivates the AM/FM radio
80
What is bore and stroke for the caterpillar c-13 Diesel engine?
5. 12” bore
| 6. 18” stroke
81
How many cubic inches is the c-13 caterpillar engine?
763 cu in
82
What is the compression ratio of the caterpillar c-13?
17:1
83
How much horsepower does the caterpillar C-13 engine have?
525 @ 1800 rpm
84
How much torque does the caterpillar c-13 engine have?
1650 ft lbs @ 1800 rpm
85
What is the normal operating range for the caterpillar c-13 engine?
1200-2100 rpm
86
At what rpm range does the caterpillar c-13 get the best fuel economy?
1200-1800 rpm
87
The c-13 delivers greater torque and pulling power at higher or lower rpm’s?
Lower rpm
88
Can the caterpillar c-13 engine run an additional 7% higher than its maximum operating range?
Yes
89
The caterpillar c-13 engine has the ability to perform what 2 things?
Diagnostics for self checks
| Continuous monitoring of other systems
90
The caterpillar c-13 engine, depending on application, can also monitor what 6 things?
```
Oil temperature
Oil pressure
Coolant temperature
Coolant level
Fuel pressure
Remote sensors
```
91
For the transmission, when all segments of the digital display are illuminated for more than 12 seconds, what does that mean?
The ECU did not complete initialization
92
For the transmission, when the display shows a “cat eye” symbol, what does that mean?
A selector related fault code has been logged
93
If the check trans code is active, will the transmission shift into range?
No
94
For the transmission, during what 3 instances you use neutral?
To start engine
Check vehicle accessories
For extended periods of engine idle operation
95
When using the display mode/diagnostic button, how many times do you press the button to obtain trans fluid level and diagnostic code information?
Once for fluid level
| Second time to obtain diagnostic code information
96
If you must leave the engine running, do not leave the apparatus until you have completed what 3 things?
Put trans in neutral
Apply maxi brakes, properly engaged
Chock wheels
97
If the transmission display flashed either R or D, the requested range has not been achieved due to what function?
Inhibit function
98
Do not idle in reverse for longer than how many minutes?
5 minutes, can cause damage to transmission
Always select neutral whenever idle at idle exceeds 5 minutes
99
You should not allow the apparatus to coast in neutral due to what 3 things?
No engine braking
Could lose control
Can cause severe damage to transmission
100
If the apparatus starts in any other range other than neutral, you notify who immediately?
Shops
101
At what speed will the transmission shift through gears at 2100 rpm?
```
1st gear 14 mph
2nd gear 26 mph
3rd gear 35 mph
4th gear 50 mph
5th gear 68 mph
```
102
A good indication that all of the moving parts are getting lubrication is when the oil pressure is at what psi at idle speed?
10 psi
103
If there is not oil pressure within 10-15 seconds after starting engine you should what?
Stop engine and check lubricating system
104
The oil pressure should not fall below what psi at 1800 rpm for the caterpillar c-13?
30 psi
105
If oil pressure does not fall within guidelines you should what?
Stop engine and investigate
106
If engine oil has signs of contamination such as fuel, coolant or debris notify who immediately?
Shops (213)485-6111
107
In the event air brake systems pressure drops below approximately what psi will a warning buzzer and light come on?
65 psi
108
As soon as the air pressure increases past this range, the warning light and buzzer will shut off
65-75 psi
109
If the air pressure is reduced to this psi the spring brakes will automatically engage
40 psi in primary and secondary
110
You should always chock wheels when parking apparatus on what 2 types of grades?
Level terrain or on a grade
111
It is department policy to chock wheels always when?
Always when on scene
112
What 2 things does the load manager do?
Maintain battery voltage by monitoring battery voltage and by controlling electrical loads
113
The engine throttle will increase to compensate for the low voltage and electrical system loads when battery voltage drops to?
12.8 volts
114
The OIC displays a message that the load manager system is in control and an alarm sounds if voltage drops below?
11.9 volts
115
Shedding of electrical loads will begin in approximately how many minutes if low voltage conditions continue?
1 minute
116
What is the first system to be shed by the load manager?
Heater/AC
117
A shed system (load) will not be recognized for how many minutes or until the unshed voltage setting is maintained for how long?
5 minutes, maintained for 1 minute
118
The fast idle system will be maintained for a minimum of how many minutes or until a voltage reading of how many volts is achieved?
10 minutes, 13 volts achieved
119
Shedding can only occur when what is set and the transmission is in what range?
Parking brake set, transmission in neutral
120
What is the load manager accessory shed voltage and sequence (4 sequences)?
1. AC @ 12.7 volts
2. Spare @ 12.6 volts
3. Front warning and left scene @ 12.4 volts
4. Right scene and rear scene @ 12.2 volts
121
For the onboard generator on the 2006, if you set the control to auto, generator will start when the house batteries are below what voltage and will run until voltage exceeds for 1 hour
12.1 volts, 13.3 volts
122
For the on board generator for the 2006, when setting the time by pressing the start/stop button, the generator logic control will crank the generator for how many seconds, and if not start in how many seconds, how many attempts?
5 second crank, 5 second stop, 5 attempts
123
If generator fails to start after fifth attempt, what will the display on the generator logic control display for the 2006?
“Gen fail”
124
For the 2006 generator, if at the end of 24 hours and no activity has been observed, the controller will exit from auto mode and generator will what?
Stop
125
What year truck is equipped with the air kwik firefighting system?
2006
126
The airkwik employs the time test technology of using what to propel water?
Air pressure
127
What are the 7 basic components of the air kwik?
```
Water storage tank
SCBA cylinder for air pressure
Aluminum diamond plate box that houses regulator
Hose and nozzle
Valves
Gauges
Lights
```
128
How many gallons of water can the airkwik hold?
80 gallons
129
What size hose does the airkwik use for firefighting?
1”
130
How many feet of 1” does the airkwik hose tray hold?
100’, tray located on both sides of apparatus
131
At approximately how many gallons of water remaining in the airkwik will the red light turn of for the low water indicator light?
25 gallons
132
The full indicator light illuminates on the airkwik when what switch is depressed?
Momentary switch is depressed
133
What 2 things does the tank pressure gauge read on the airkwik?
Discharge pressure when flowing
| Static pressure when discharge valve is closed (0-300 psi)
134
When does the air cylinder pressure gauge work on the airkwik?
Only when cylinder is turned on (0-5000 psi)
135
What is the regulator control knob typically set at for the airkwik?
150-175, 200 max
136
The alarm shutoff switch should always be in the ON (white for depressed) position for the airkwik except for when what 2 instances?
To silence horn when refilling
| When vehicle is being driven with tank partially full (sloshing of water activated low water warning horn)
137
The alarm shutoff switch on the airkwik must be in the ON position to operate what 3 things?
Full light
Low light
Low water warning horn
138
What size battery does the airkwik take?
12v alarm battery
139
What tool is equipped with the airkwik to assist in removing fill cap if necessary (keep hand tight)?
Folding spanner
140
What size is the fill cap for airkwik?
1 1/2”
141
How do you open the air bleed valve on the airkwik?
Lift locking collar and turn handle
142
You should always bleed all residual air pressure from tank of airkwik before attempting to what?
Fill or remove fill cap
143
What is the quick connect used for on the airkwik?
Hose and air muffler used to avoid getting water in compartment during refilling
144
What is the water pressure tank rated at working pressure for the airkwik?
200 psi
145
What kind of stainless steel is the airkwik constructed with for maximum corrosion resistance?
#304 stainless steel
146
What is the exterior of the airkwik finished with?
Powder coat to give durable gloss red finish
147
You should never put these 2 types of solutions in the airkwik as it could damage the stainless steel?
Chlorine or any salt solution
148
The airkwik is powered by a high pressure air cylinder of what psi?
2216-4500 psi
149
The cylinders are connected to the air delivery system by what to direct pressure to gauges, regulator and water tank of airkwik?
Teflon lines double braided stainless steel hose and connector
150
How many SCBA cylinders need to be open for normal operation?
Only 1
151
For maximum pressure for the entire 80 gallons how many SCBA cylinders should be turned on?
Both air cylinders
152
Will the water tank remains pressurized even after all the water has been expelled?
Yes, air must be released by opening air bleed valve
153
Prior to removing fill cap on airkwik, always check that the gauge reads what?
Zero
154
How is the air bleed valve normally kept on the airkwik?
Closed
155
You should always ensure that what is closed before bleeding tank of airkwik?
SCBA cylinder valve is closed
156
Part of the pre check procedures should be to ensure that what is in cap in order for the cap to be air tight for the system to operate and should not be worn or cracked?
Rubber gasket
157
When bleeding the airkwik do not rely on exhaust noise stopping due to the fact that the air muffler could be what?
Clogged
158
If air muffler is clogged on the airkwik, remove air muffler and bleed tank by doing what 2 things?
Slowly opening valve to bleed air or air can be released through discharge valve by opening very slowly
159
Where are the 2 safety relief valves located on the airkwik?
Air pressure regulator
| Tank
160
The automatic tank pressure relief valve relieves at what pressure in the event of a regulator malfunction or tank overpressure situation?
250 psi
161
How many seconds will the low water tank warning horn sound for on the airkwik?
First 3-5 seconds
162
How long will the red warning light stay on the airkwik?
Until tank is refilled or gauge shutoff switch is turned off
163
What are the 7 daily checks of the airkwik system?
Water tank full
Fill cap hand tight
Bleeder valve closed
Air cylinders full, connected and secured
Regulator set to desired pressure
Hose and nozzle in good condition, properly stowed, nozzle in OFF position
Air test cylinders, open each for few seconds and listen for leaks
164
How long will the water last on the airkwik if it supplies both 1” lines simultaneously?
Half as long
165
Is hydrostatic testing required on the airkwik tank?
No
166
How often is a visual inspection conducted on the airkwik tank?
Every 5 years
167
Can the airkwik tank deteriorate when spilling foam concentrates on it?
No, due to powder coat
168
How often shall the tank be pressurized on the airkwik to activate piston in regulator?
Monthly
169
How often do you make a visual inspection of the “O” ring air cylinder connection fitting?
Every time an air cylinder is replaced
170
How often should you check hose fittings and braided hose jacket for signs of wear for the airkwik?
Monthly
171
What is EPU is rated for a maximum of how many minutes continuous use?
7 minutes
172
The EPU can be used over a longer period of time at what percent duty cycle which is approximately how many minutes every 10 minutes?
23% duty cycle, 2.3 minutes
173
What should the tire pressure be for front, rear and tiller?
Front-100 psi
Rear-95 psi
Tiller-115 psi
174
For the lifting wench on the 2009, rotating it clockwise and counterclockwise gives you what speed?
Clockwise-low speed (heavy loads/low torque)
| Counter clockwise-high-speed (lighter loads)
175
How many wraps do you go around the drum of the lifting wench while working from top to bottom?
4-5 wraps
176
How much are the anchor attachment points rated at in the 2009 fifth wheel?
9000 pounds
177
In the event of an electrical failure, the outrigger controls and the aerial controls will become disabled because of the interlock system, the circuit selector (blocking solenoid) requires how many turns to the left or right for engagement?
1/4
178
The EPU needs to be activated if there was what type of failure?
Hydraulic
179
The rotation interlock override (left and right) are used to rotate the aerial while utilizing the EPU during an electrical failure, the ladder can be moved how many degrees past the tiller cab toward the short side and how many degrees past the tractor cab toward the short sides?
8 to 10 degrees past tiller cab, 2 degrees past front cab
180
For rotation limiting system, in order to allow for cradling of the ladder, there is approximately how many degrees of rotation travel past the vehicle centerline?
4 degrees
181
For rotation limiting system, both rotational directions are allowed but swinging toward the short set side will be cut out after approximately how many degrees of rotation?
4 degrees
182
In the event of an electrical failure, it will be necessary to activate what solenoid mounted forward of the turntable rear step?
Blocking solenoid
183
15w-40 oil quarts capacity for 06 and 09 truck?
42 quarts with filter
| 38 quarts without filter
184
Road transmission ATF dexron 2 capacity for 06 and 09 trucks?
57 quarts
185
Drive axle 90w-140 quart capacity for 06 and 09 trucks?
23.6 quarts
186
Axle hub 90w-140 oil capacity for 06 and 09 trucks?
2 quarts
187
Engine coolant gallons capacity (S and M supplied coolant mix) for 06 truck?
10.7 gallons
188
Power steering reservoir 15w-40 motor oil capacity for both reservoirs on 06 and 09 trucks?
8 quarts (4 in each)
189
Engine coolant quarts capacity (S and M supplied coolant mix) for 09 truck?
43.6 quarts
